VCDS coding problem or something else

[Youngc29]

Hi, first real post....so here goes, had an evap lower limit fail that I managed to fix by replacing the N80 valve and hose myself, (happy with that) but a few months ago I had an issue with a constant battery drain, that turned out to be a water damaged electric door module on drivers side. This was replaced and all seemed well.
Until I got my VCDS cable and fixed the evap problem I wasnt aware that there was an issue with the safe motor on both front doors. I understand what this motor does but I believe the electric window module replaced wasn't coded in the shop properly so I would like to ask what It should be coded to on a MkV GTI my08 (German built).
I will try and attach my latest scan, I have also just tried to code it as 1680, to see if that helps....but I believe that it does have a safe motor installed correct?

Thanks for any responses


Chassis Type: 1K0
Scan: 01 02 03 08 09 15 16 17 19 25 37 42 44 46 47 52 56 62 72

VIN: WVWZZZxxx Mileage: 58980km/36648miles

01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
37-Navigation -- Status: OK 0000
42-Door Elect, Driver -- Status: Malfunction 0010
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
47-Sound System -- Status: OK 0000
52-Door Elect, Pass. -- Status: Malfunction 0010
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000

-------------------------------------------------------------------------------
Address 01: Engine Labels: 06F-907-115-AXX.lbl
Part No SW: 1K0 907 115 Q HW: 8P0 907 115 B
Component: 2.0l R4/4V TFSI 0010
Revision: 5BH16--- Serial number: VWX7Z0G43NN880
Coding: 040300431C070160
Shop #: WSC 66565 257 00032
VCID: 346318E32EAB

No fault code found.
Readiness: 0000 0000

-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 02E-300-0xx.lbl
Part No SW: 02E 300 043 Q HW: 02E 927 770 AE
Component: GSG DSG 081 1305
Revision: 04508010 Serial number: 00000704240216
Coding: 0000020
Shop #: WSC 44551 111 44551
VCID: 224FEEBB845F

No fault code found.

-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 1K0-907-379-MK60-F.lbl
Part No SW: 1K0 907 379 AC HW: 1K0 907 379 AC
Component: ESP FRONT MK60 0101
Revision: 00H11001
Coding: 0004738
Shop #: WSC 00046 412 00000
VCID: 73E1DBFF6B25

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 1K0-907-044.lbl
Part No SW: 1K0 907 044 BS HW: 1K0 907 044 BS
Component: ClimatronicPQ35 120 1111
Revision: 00120021 Serial number: 00000000000000
Shop #: WSC 00000 000 00000
VCID: 79FDE9D74949

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels: 3C0-937-049-30-H.lbl
Part No SW: 3C0 937 049 AJ HW: 3C0 937 049 AJ
Component: Bordnetz-SG H54 2202
Revision: 00H54000 Serial number: 00000007100958
Coding: E58D8F2700041500471400001400000000087F075C00010000 0000000000
Shop #: WSC 00046 412 00000
VCID: 71EDD1F71139

Part No: 1K2 955 119 E
Component: Wischer 120707 020 0501
Coding: 00049109
Shop #: WSC 00046

Part No: 1K0 955 559 AB
Component: RLS 070507 020 0105
Coding: 00208933
Shop #: WSC 00046

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags Labels: 1K0-909-605.lbl
Part No SW: 1K0 909 605 T HW: 1K0 909 605 T
Component: 1P AIRBAG VW8 020 2300
Revision: 05020000 Serial number: 0038PD160U00
Coding: 0012624
Shop #: WSC 00046 412 00000
VCID: 3D753DC71DE1

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 1K0-953-549-MY8.lbl
Part No SW: 1K0 953 549 AQ HW: 1K0 953 549 AQ
Component: J0527 636 0070
Coding: 0012122
Shop #: WSC 00000 000 00000
VCID: 810D0137A199

Part No: XXXXXXXXXXX
Component: E0221 002 0010

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments Labels: 1K0-920-xxx-17.lbl
Part No SW: 1K6 920 874 HW: 1K6 920 874
Component: KOMBIINSTRUMENT VDD 1216
Revision: V0002000 Serial number: VWX7Z0G43NN880
Coding: 0003103
Shop #: WSC 60074 959 65905
VCID: F0EB54F39A33

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 1K0-907-530.lbl
Part No SW: 1K0 907 530 L HW: 1K0 907 951
Component: J533 Gateway H07 0052
Revision: H07 01 Serial number: 040607F1001408
Coding: ED807F065002020003
Shop #: WSC 60074 959 93514
VCID: 306B14F3DAB3

No fault code found.

-------------------------------------------------------------------------------
Address 25: Immobilizer Labels: 1K0-920-xxx-25.clb
Part No SW: 1K6 920 874 HW: 1K6 920 874
Component: IMMO VDD 1216
Revision: V0002000 Serial number: VWX7Z0G43NN880
Shop #: WSC 00000 000 00000
VCID: F0EB54F39A33

No fault code found.

-------------------------------------------------------------------------------
Address 37: Navigation (J0506) Labels: 1T0-035-680.clb
Part No SW: 1T0 035 680 D HW: 1T0 035 680 B
Component: RNS-MID H11 3970
Revision: AB001001 Serial number: VWZ6Z7Z5604521
Coding: 08010000010000020000
Shop #: WSC 42595 146 50733
ASAM Dataset: ------------------------- ------
VCID: 2F69178FC78D

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver Labels: 1K0-959-701-MIN3.lbl
Part No SW: 1K0 959 701 M HW: 1K0 959 701 M
Component: Tuer-SG 006 120B
Coding: 0000640
Shop #: WSC 00046 412 00000
VCID: 387B2CD332C3

1 Fault Found:
00096 - Drivers Door Central Locking (Safe) Motor (V161)
012 - Electrical Fault in Circuit

-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1Kx-909-14x-44.clb
Part No: 1K2 909 144 M
Component: EPS_ZFLS Kl.069 H08 1901
Shop #: WSC 00046 412 00000
VCID: 366722EB38D7

No fault code found.

-------------------------------------------------------------------------------
Address 46: Central Conv. Labels: 1K0-959-433-MAX.clb
Part No SW: 1K0 959 433 BT HW: 1K0 959 433 BT
Component: KSG PQ35 G2 020 0204
Revision: 00020000 Serial number: 00000000000000
Coding: 819002005103087F2D04840570085FC690FC00
Shop #: WSC 00046 412 00000
VCID: 83010B3FBB85

Part No: 1K0 951 605 C
Component: LIN BACKUP HORN H03 1301

Part No: 1K0 951 178 A
Component: Neigungssensor 003 0203

Part No: 1K0 951 178 A
Component: Innenraumueberw.003 0203

No fault code found.

-------------------------------------------------------------------------------
Address 47: Sound System Labels: 3C0-035-456.lbl
Part No: 1K6 035 456 A
Component: 08K Audioverst. 0005
Revision: 00003000 Serial number: 00000000136227
Shop #: WSC 00000 000 00000
VCID: 2A5F069BFC6F

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. Labels: 1K0-959-702-MIN3.lbl
Part No SW: 1K0 959 702 M HW: 1K0 959 702 M
Component: Tuer-SG 005 090B
Coding: 0000640
Shop #: WSC 00046 412 00000
VCID: 397D29D709C9

1 Fault Found:
00097 - Front Passengers Central Locking (Safe) Motor (V162)
012 - Electrical Fault in Circuit - Intermittent

-------------------------------------------------------------------------------
Address 56: Radio (J0506) Labels: 1T0-035-680.clb
Part No SW: 1T0 035 680 D HW: 1T0 035 680 B
Component: RNS-MID H11 3970
Revision: AB001001 Serial number: VWZ6Z7Z5604521
Coding: 08010000010000020000
Shop #: WSC 42595 146 50733
ASAM Dataset: ------------------------- ------
VCID: 2F69178FC78D

No fault code found.

-------------------------------------------------------------------------------
Address 62: Door, Rear Left Labels: 1K0-959-703-GEN3.lbl
Part No SW: 1K0 959 703 K HW: 1K0 959 703 K
Component: Tuer-SG 006 1201
Coding: 0000144
Shop #: WSC 00046 412 1012557
VCID: 387B2CD332C3

No fault code found.

-------------------------------------------------------------------------------
Address 72: Door, Rear Right Labels: 1K0-959-704-GEN3.lbl
Part No SW: 5K0 959 704 HW: 5K0 959 704
Component: Tuer-SG 007 2106
Coding: 0000144
Shop #: WSC 00046 412 1012557
VCID: F2EF5EFB943F

No fault code found.

End ---------------------------------------------------------------------

[Youngc29]

3 days later the main fault came back :( p0441 - 002 lower limit exceeded
someone also suggested the N75 valve Volkswagen Golf V 2.0T > Search > N75 > ES#257544 Waste Gate Frequency Control Valve (N75 Valve) - 06F906283F (http://www.ecstuning.com/Volkswagen-Golf_V--2.0T/Search/N75/ES257544/)
or pipes around charcoal canister (checked) or the canister itself, any ideas? am I in the correct forum here?? or is it "nobody knowwwss"

[Umai Naa!!]

In regards to the door module, has it been basic set? Does the window on that do auto up/down?

Also, check for broken wires where the wiring passes from the A-pillar, though to the door.

[Youngc29]

Hi, sorry for late response, yes the window goes auto up/down, basic set? is that the tests you can run from vcds...yes I think I did run that.

cheers

[grtuned]

Check your coding on the other front they should be the same !!!


Sent from my iPhone using my fingers.

[Youngc29]

unfortunately fault shows up on the other door also, I don't remember what the original coding was, if it's a genuine fault or if it was due to my messing.
If anyone can tell me what the original coding should be for my car that would be super fantastic, then I could code both doors and see if the fault is related to dodgy replacement of the module (I reckon it probably is I took it to the RAC :) )

[grtuned]

Attach a print out of door lock modules coding via vcds.


Sent from my iPhone using my fingers.

[Youngc29]

I must be tired but how can I attach a screenshot here?

---------- Post added 12-02-2012 at 11:24 AM ---------- Previous post was 11-02-2012 at 11:11 PM ----------

http://www.vwwatercooled.org.au/forums/image/png;base64,iVBORw0KGgoAAAANSUhEUgAAAR4AAAC5CAIAAAB xxcdjAAARz0lEQVR4nO1aUbLjOA7LpecIfYM9xFxrT+L9mJq3j kiCICXZTh5SqJQjSxQIEvZru1/H8V9BEJbj9fff//nz56/beQjCl+H1589fr9frdh6C8GWQqQRhC3xrvf79XDDyz2CN9PtnV gITIR1ZS4BUgBSN5wMiMNn9nJpR4J+17o6NdnKZzAty5skHSaj YiGtHftRp1KOhXVVQcscd9m5nvcRapWnt9EGEmXbaUYW+tVyWp axmRlZZi7yqpa1jbU9aK9oOE7Or3MuNu6kNXlWDzM6N4+7u/sTp2LNkgZhoS6owiBCFepuDmbmyLhwByrqVA6dIAnydBh17BGw oTDVtEVJkvhxu+jZBhjNfcXsqqrU707JtC0VWgdR26IeCiMtHX C1SRBLY8oDUwO58W2ACUfOltXGbrNQxWHzbB+2NgBqkhrgBSiU r8bcKRNW02oK++n9wzIyp08wIlo9pMreuTCJpnaptAQiUrGUZl jqmZK1UtxLn5dbix3vWwmWKVCV3f661ANLOtrWfsVbD27j5SGu BTdNQfDmq1rJibrJWOp9sp0Z/RskyC0dr2ayGfto3EikLEC2PtnNFsZTcpnEXkgTwwTATZOFSjV oqVQOwigSJxBwOwBZYQ7cEbrI4I7CRyyStwrA8ZfI2x9ZPEK7B 4IHHxmwyuZ2B8Jux1gnP8dUhawnCJshagrAFspYgbIGsJQhbcP/Dd/f5aUI6mEwGqe7VYEhu3Ytpnyan06ob8fPPz6Mn1ejN5BO8+CFH 8qoueiewb2RG6N0Pc+fjf4q12hldv8vTrRU10JOtNdxPhnuL/Wk3BXMiVtHatdGG1M6DaRauwlh/u100Pmw3HPO5tHdJdU51uww3Wwt3RlSVNL57KiqGO8dVo5psml RDumFVVLhhQkrSFadKjC96u3OiU7xul2G20stHSNKMjjNJLeyG NNpAuBTfZhpNSxWLVpFUGyVOd3EXugQiNXoNtgThxaCq16oRV8 Fqf1sRq2Sq3XBltKj73b3WWiuNsMpaLqtUB6bul+G51kKkK9Za aIZ2/ChHS5tJDXe/uzDdqGqtKMISa5GXgOq14x5r2Q4YqFw5kpOOdRyktCWxcrtzLD 3bFjiRKJr7020Uck4kIJjsjoNVOALm4wbBdXSD4BSAGpbhNbh0 M0H4PZC1BGELZC1B2AJZSxC2QNYShC2QtQRhC65++H54T2DdZ8 cU+2zVkuet7nNkrFs7o7V8hBuRvHuJ3jz0Rg7z5g689MipEy8r 1lqrOnNT68tRH4Hkvd5aawHLdajDaPbuYX+604aZw7EbKkoH6A DubFU+4BImE96IS63lHoM2TVuQZx71t52TBol2jDjzylSFrSov XImX7YaLreUeM7ztcdVa0fJIEJtXxIo0vBsNlAMQjvjLWnfh/ruWe3xk/eGeXWKtdCZjLXJrN2swOYoMkhXuwnOthUgH3TZctg+uv/G1H0ywTLC13BtRFAFMBknNqCqsha+7vVesGjniu1OBNLyQn/vvHHnYCB+4QaJQILUoIM4Fb0datKqqsBaSXhC2QNYShC2QtQRh C2QtQdgCWUsQtkDWEoQtuPrhOzOSk87ea00pAl8VlFitmg9m8o nrQfzFcOS2b0uuHKFIe+ZcpshV1mpTsqdkrQeCeq+/wzbMSEg6sBb+/pl5/mn3jX7i+62NTG70On3mI0ehSvIKS3CDtYbau3OO956LmjL6Hlo N5GWZvMynmi+/0ZLI5EJZ62LMtlFpZNgY/ExJp982LGaIibk+j3TDkjIqDU4Yjm3kiCQugbAVN9y18I7nQdv NNv5l1kr5n42BY5Iq2YDRpjxJ4TJcaq3oCl0mHfTcNdayRgLWa ty1GNNGd62UpHAZfLntvWLTyOv9w5JuWcvdHQS3W7i5nPeNJpe sFakUbVoiKVwGyS0IWyBrCcIWyFqCsAWyliBsgawlCFsgawnCF tz88P08XiBdf15PRosCus+vSz9JJvNLcAq9tSWq/LP+734fkLzYid69rBr5Oa5aa2F52v3EJ7ixfhNmmGEoa+XZ2SS vsVajElFJfn6mN0nm5hMxx6Hcn5gAiBklUiI/LDkHd7ViCLhrU2XIXL4MV1vLFdpV+fX+sR3QJsBsZPsDb8HPH+ bY+XgXLAVYArKbKS7OopTLl2Hoq133qFKFGNL2Z5VAFM0dxwHT BgLalqJFua9SA2w3OGE4tjme/cwo8H24+q5lRwbp3YLhfnqstXiTPN9aw0974GYRbYGV/w7cbK2eym6ctdYa5rs/o+Vu/y2xVnqVAUtmrIUpuRs1cvkyhBfsIfN9I0OFKNKnT4l25KIhIGj 6aEKUi9tw7jQ8x90ak0+3dgXEBGzwaKNoIcjly/DNuX0lGu343R38WEj0D0B0l167RFgL6S4IWyBrCcIWyFqCsAWy liBswd6H70f8sBivynnH/0zf8S94++h5VdjdBRbuQvIKNXrRwYwc5s0JuYriHU9ux+QDyhJ CiuS/F8xYC3fhjLXwzOi2md4wXcLuXj8zJ2/sgJvw6dhoLXv8tnHWVa/3T3QKRG6k4NJwtwCGnLn6yF1fg6GBZ7vkPGKP7eB8V6Vm6KVA8 h9ysTcl96IQrb2s6sIFuOGuRc4Edy0bLbo0tFMA/EvpYwXSmcLn4mprgZ98YzWs27ZWdW3j5j9/6xYeiLCZ7J8ujZHD9I29EaX3JZKhu0spKcABzASm4nfsiSA8Ga qlIGyBrCUIWyBrCcIWyFqCsAWyliBsgawlCFuw9+E7GFn18L20 0E5mRnZJ33qP555iQunJ/sVo/leD3shhCuzOyUl3/xODayTr/NurktIGUjeCCDuw/X9jRHOimRTp+L9NgNume5cD1rJ31/NgtMuQLJCFDGiDR3sBBdpSC21cba2oUdwl6Vm7BU/SjmNL2B5NZ2JZGtpGp5iFstbFGBp48Z9/7k9yFc/ezcQOulsAa0VrGWvhTFMFBicMx5ZVyrknrzCD7XetqKKMIa1Vy FBMInbcfrvRLrAW3hEzxwoIl2GvtaJewaty0sW/rNyreESVicZLAVJraBtlxCsgXIbwljIUozHi3naYOBRvExkEP9 7/ZBrigIOBeXWm3cUOWj9ESkYZgYV2vnAZJPclKqutfx9U8v0Sy1 e/Eqq6IGyBrCUIWyBrCcIWyFqCsAUbH76fR9xHzNGqnPT7xw0bbc eM9B48uGFJko3gwsMRvm85H/dGjrjbwF4U6YoT7rKW+1MO+T1wPLDKWlEH87eXkDTs2uEl6c/3+YCxgZ0c3YTdvMBNzP3pTnCzIAkI92KvtZg+jsZf75/01EBj8FJE1Q3YyNqSdAcHJoyAMwSEGzHbUmBk2AacjQYB6Shsd cTdfejXkjKRxCDy2UjzhRAego13rbdt6LPnwaHVcLTl1lrb2cN 8RgRZ66Ox9w9CEDP6SZEmrEVe+wGlUijsf3f+WpEtAeFeoL9hh kIuGTlMf5w/LOmKE9x2ZGzAhLJzXBldA6RyMdbCBIQb8c3F+G2t9tvyfTi+rR iNe+BH47fl+0FQPQRhC2QtQdgCWUsQtkDWEoQtWPnw/fCeYjOr7MKcN/3PdyYyz2fH04IZNcBM/om8HoHsgKMp8zoFv2Dh47gLc9L0S2cyrOv/mYC1GkzElLUei/Dt5PmYH8Fx3jYO/hcFRTru+7Mr8E+70P15XpXGt9zcuyuIOYQqrcV8olBV8QUSy6z FHw8jUXVf7x/3rBvQBifJRN8uT/cUSJMUsyo75kMulLV2YGjgckUbx4fXEL3qupdhe+W2edo44NtN nHFIQ8xUZJtylP7wnVZZWIsb7lpRN1j7ATMMM6MtgHVBFzKJ32 UtJkGcCK6IsApXWyuqYqm6bp+513XQeW7A4eBp1mL4gOtFKpew EGGjD4ozI4fX9EOjnz9gYc7bizN01WFaKmojYEU3hegUiEzGPM +srsWmYuQSFkKaCsIWyFqCsAWyliBsgawlCFsgawnCFshagrAF Kx++MyM/4+kcRPr0sQHTtXzYdigwufGke+bh+My+wgwWvOXkR36O3Xr37F HtGGytUtietS6GHHUXkhav2iadY99jgjgh6YCPe9tx72/MvdRl+7PQhgX7DscRseieyWeX7hsVxd1XmMHN1jrgH41Rt0V8S OYDGRzWnWxNwivWkLSU3cJ9hRkMDTz7x97BNRyYUyXN80x3jMI y6QAN3ZSXWMtyTvdlyAtLsPiulcZJbXz+GZU8aqB5a5GTbXeCh cPIQmuV8gXWAv0htLHSWqBTo1NgDiLdshbZwUwKoDvTfXdYC1y qUql7JRBS+FLae0U64t5k3HvOYcrpzkGkaWu5PKM4mGeUckmfG WIgOxwWLG+XQEghNQVhC2QtQdgCWUsQtkDWEoQtkLUEYQtkLUH YgmUP38/jS+Ig0u+faI470njEvDBUb7vGTJ6hOydajsfdGk2OtMW5HaGsk ZT4JcnwRqUdJyHd6ph2Vdzy3145nNGMtc4V5IsbxeRLTzbDQ8T PhcVKlVQYTlXjFEgHF1q39j+Dw3d0ybTx8bToO6IUnbXKRAyHC b29QLJp4qBhomJVmwHH77XNxbjfWqDDorN2PNpr6C0mI3c7/O2ujZLFgpc0J9NvJNsIFXZYsYUwpWjkgRgauH+BsWXG2gF9GdJ ghGkFstLRQhwKUxqkj7ID6kVbWGHPliZl563FlAw0AzkyMK+2y o1ILqIzKmAtmBq7soJoNvKTrTWjTHSQMsQ8q6Fwi883FVPux2K ZtezPyThkzfBeZzKktYCTh4MZa5FOJkdwmr1kQeJMyUjHNvTB+ z4HPsXXv5/SiCtKOw4iHVz+z3Gq3WZnuhPOB7ghACVGQMDQNQZOM5IdJAsSx 4U4b2cZLmmGUrfchQ+geIMon1C5X5v+w+n9n+ftDB4Ce5X9zXi sCI8l5lC9nYEgfCVkLUHYAllLELZA1hKELVj58N19DJA+cW48P LCT1/7r1n0qDSYvf/jBb30Nn2jfSCjm6fnMcyN+CZjJV7knpl8bsD0/8qNgKTKplzVnI/m1oi/k0LbWJj543/aV7oLHffdbq2oAfgRH7iUArDVcCO2lEVwC3Isx4Byl8PNtSUbX +/PZKAWbb8pnhyYDVTdfQB4QBjtGOkfiMEqCEmCdSSyzVqQjjswI HcWMvqvMoxGQKU4B1A/MieoNTqV81mpiWeF8cbnT3ogk6iVSrTLQmcTQwCsbNBIFuIUnH UnTyCVa5bYL5oz7MiIGaDPVwRryCjT2xSLbICk3pqOYUkZhoyq XdCYReprRjhEiopXOAYVxpVnI3PaZSzIawVuUBOcXAhmZSvX2J QWMsMNaLsOUZElnEpdaC5SnRjoQ7vwz5WnnDCPtC8T5WlCSy6W U8sd8VlUKW8vNNxUw3TFqkkZb4ipXdWYQdswQsTfiijJIdv6wp ONrkiscnsPLzWtlS2ITt0HctZHOEau0LlFeaaUAW8sZtERpR3d 5Wlxb2bTKVZ1TdNb8QpTE7VVC+DIZP5v9RRoVa/zpPfEQfLqMn81eEB4LWUsQtkDWEoQtkLUEYQvYh+9H9qiUmfN6/4A4OW8vDrnQ/mxHA6xm/hU+Q4NfAmbyD53dOdFyPO4qCUbcamLlr3w0wr7Is3n25tgljbQ je/TWzkTbVLlrOmCTtUA/kHW3Zyf77Xptj6PyvzEiTtEcxlq9nNOLnP15HrTj7WgMMSuUvb ieR4ZjTCnasbQLyNE9e07/FVc2WoJ7A3RXr9+YMu0AZS1AEStLxnHHX+8ffmu3DLioS6INnM FyfoRfMr+LPcUsTBuADBWhZ6FHWMt28Iwl2tbqZQuauJGRG63R 1lgcpr12WGtIkFHs55vUE1B1MyV9RVbQ3XpgTu67BFN3rcZa3l eRLtHyhhkAma+0VlSLkh94BSat1bMTU+VHW6t9vCRP3EznA9Bn ESXGWnitOwLIgJGF1kp3sSSZham1Uqn5Es8fp/suRHgjwqq150QTbKiEt1nlHrvNEQ3iaLbdyZphMtEWbhO7PeqW oLRLRDJaGMkI9gVUcXEBB6bfovh8p7VxxR5fhmsK87l4uD6X0X u0Cs/Ew1vnCXisRFcSe6gEgvDpkLUEYQtkLUHYgv8B2G/cPW97bsAAAAAASUVORK5CYII=

---------- Post added at 03:43 PM ---------- Previous post was at 11:24 AM ----------

need to put this issue on the back burner, thanks for responses....
car made a crazy loud screeching noise last night, RAC guy came out and looked this morning, said I need to tow it to VW looks like the drive belt tensioner or timing belt tensioner, thing is I had strange issues when the car only had 37K on it and VW replaced timing belt (iv seen this on youtube) and other belts back then on warranty.
Also car just had it's 60km service few weeks ago and when he checked the oil this morning it was on minimum! I know the 2ltr FSI burns oil but surely not this badly, that's another issue :( It's been a great car though with very little issues

---------- Post added at 05:54 PM ---------- Previous post was at 03:43 PM ----------

mmmm after some research, I think the RAC guy may be wrong, it may be the PCV valve from what I have read on all the forums its sounds similar
http://youtu.be/M2-3QL_45ac

EVAP, oil usage and the noise may all be related to this one little valve, btw I know nothing about cars and engines, so just guessing here, Im not sure if I take it to the stealer or just try and fix it myself, does anyone have a part number for a new valve?

[Youngc29]

Was a bearing that sheared on the timing belt tensioner!